Product ID:WD-40 BULK LIQUID
MSDS Date:08/01/1992
FSC:8030
NIIN:00-835-4348
MSDS Number: BPFFF

WD-40 COMPANY

1061 CUDAHY PLACE (92110)
SAN DIEGO, CA 92138-9021
US

Emergency Phone: 800-424-9300

Info Phone: 619-275-1400

Preparer: R. MILES,TECH. DIRECTOR

Cage: 09137

WD-40 COMPANY

80607 SAN DIEGO, CA 92138-0607 US

Telephone: 619-275-1400

Cage: 09137

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 70%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY

CAS: 64742-65-0

RTECS: PY8038500

Fraction By Weight: >20%

ACGIH TLV: 5 MG/M3 (OIL MIST)

NON HAZARDOUS INGREDIENT

Fraction By Weight: <10%

LD50 LC50 Mixture:NONE GIVEN BY THE MANUFACTURER
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE ANESTHESIA,
HEADACHE, DIZZINESS, NAUSEA AND UPPER RESPIRATORY IRRITATION. SKIN
CONTACT: MAY CAUSE DRYING OF SKIN AND/OR IRRITATION. EYE CONTACT:
MAY CAUSE IRRITATION, TEARING AND REDNESS. INGESTION: MAY CAUSE
IRRITATION, NAUSEA, VOMITING AND DIARRHEA
Explanation of Carcinogenicity:THE COMPONENTS IN THIS MIXTURE HAVE BEEN
FOUND TO BE NONCARCINOGENIC BY NTP, IARC AND OSHA.
Effects of Overexposure:EYES:IRRITATION,TEARING,REDNESS. SKIN:
IRRITATION,DRYING. INHALATION:ANESTHESIA,HEADACHE,DIZZINESS,NAUSEA
AND UPPER RESPIRATORY IRRITATION.
INGESTION:IRRITATION,NAUSEA,VOMITING, DIARRHEA. ASPIRATION H
AZARD:IF SWALLOWED,CAN ENTER LUNGS AND MAY CAUSE CHEMICAL
PNEUMONITIS.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH SKIN SENSITIVITY
OR RESPIRATORY CONDITIONS MAY BE MORE ADVERSELY AFFECTED.

First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
SKIN: WASH WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR.
GIVE ARTIFICIAL RESPIRATION IF NECESSARY. IF BREATHING IS
DIFFICULT,GIVE OXYG EN. INGESTION: DO NOT INDUCE VOMITING. SEEK
MEDICAL ATTENTION.

Flash Point Method:TOC
Flash Point:110F,43C
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:USE CARBON DIOXIDE, FOAM, OR DRY CHEMICAL
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE STATED BY THE MANUFACTURER

Spill Release Procedures:ABSORB SMALL QUANTITIES WITH SAND, EARTH,
SAWDUST. LARGE QUANTITIES PUMP INTO TANK.

Handling and Storage Precautions:KEEP FROM OPEN FLAME. DO NOT TAKE
INTERNALLY. AVOID EXCESSIVE INHALATION OF SPRAY PARTICLES.
Other Precautions:NONE.

Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH/MSHA-APPROVED
RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE IF TLV IS EXCEEDED.
Ventilation:SUFFICIENT MECHANICAL (GENERAL) AND/OR LOCAL EXHAUST TO
KEEP VAPOR CONCENTRATION BELOW TLV.
Protective Gloves:RUBBER,NEOPRENE.
Eye Protection:SAFETY GLASSES.
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
REGULATORY INFORMATION: ALL INGREDIENTS FOR THIS PRODUCT ARE LISTED ON
THE TSCA INVENTORY. SARA TITLE 3 CHEMICALS: NONE. CALIFORNIA PROP
65 CHEMICALS: NONE. CERCLA REPORTABLE QUANTITY: NONE. RCRA HAZA
RDOUS WASTE NO: NA.

HCC:F4
Boiling Pt:B.P. Text:300F,149C
Vapor Density:>1 (AIR=1)
Spec Gravity:0.800 @70F
Solubility in Water:INSOLUBLE.
Appearance and Odor:CLOUDY, LIGHT AMBER LIQUID, CHARACTERISTIC ODOR.
Percent Volatiles by Volume:74.0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE STATED BY THE MANUFACTURER
Hazardous Decomposition Products:CARBON MONOXIDE AND/OR CARBON DIOXIDE

Waste Disposal Methods:CONSULT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND LOCAL REGULATIONS.
INCINERATE LIQUID, BURY SATURATED ABSORBENT IN LAND FILL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.